February 18th, 2025 
Editor/Publisher 
Motion Control – Van Nuys, CA –Magnetic Sensor Systems (MSS) has released 18 low-profile Push/Pull Clapper Solenoids with the ampere turns (windings) adjusted to meet the specific force and duty cycle requirements of an application. The S-66-100 Series of Low-Profile Clapper Push/Pull Type Solenoids from MSS are just 1.00 in. in diameter and 0.66 in. deep.
February 11th, 2025 Editor/Publisher 
Motion Control – Vaughan, Ontario, Canada – Kollmorgen, a global leader in motion control systems, today announced the latest update to its AKD2G servo drive. With the introduction of these new features, Kollmorgen has broadened its offerings to additionally support PROFINET IRT and Ethernet/IP with CIP Sync alongside CANopen®*, EtherCAT®*, and FSoE time-synchronized communication protocols. Each protocol is rigorously tested with a variety of motion controllers and certified by industry standards organizations.
February 4th, 2025 Editor/Publisher 
Van Nuys, CA – Motion Control – Newly released from Moticont, the miniature GVCM-019-022-02 Linear Voice Coil Servo Motor, is just three-fourths of an inch (19.0 mm) in diameter and features a half inch (12.7 mm) stroke. This very small linear actuator, also referred to as an electric cylinder, features 8.4 ounces (2.3 N) of continuous force and 26.6 ounces (7.4 N) of peak force at a 10 percent duty cycle.
January 27th, 2025 Editor/Publisher 
E. Longmeadow, MA – — Motion Control – CeramicSpeed Insulated ball bearings are custom made for electrical motors and your guarantee against damage caused by stray currents.
The ceramic balls used for this product series are non-conductive and have an insulating ability of 15 kV per mm – higher than that of atmospheric air.
Bearings from competing manufacturers with an insulating coating typically have an insulating ability of up to 1 kV; provided that the coating is not damaged – for example when the bearing is mounted. In practice this protection isn’t always sufficient, meaning that these bearings are also vulnerable to damage by stray currents.
In addition to being protected from the passage of electrical currents, the operating temperature is 10-20 °C lower, and the resulting is a bearing life typically 4-8 times longer than traditional steel bearings.
See the Youtube Video CLICK HERE
About LM76 and “The Engineering Edge”
Founded in 1976, LM76 has been a leading designer/manufacturer of motion control linear bearings, slides and linear motion systems. LM76 is renowned for its industry leading Minuteman PTFE Composite linear bearings. LM76 is a leading supplier of precision linear shafting: RC60, 300 Series Stainless Steel, and ceramic-coated aluminum shafting. LM76 also offers several FDA/USDA compliant linear bearings and slides for the food processing, pharmaceutical, medical, and packaging industries.
For additional information contact John Tarbell at: LM76, 140 Industrial Dr., E. Longmeadow, MA 01028; Telephone: 800-513-3163, Fax: 413-525-3735 or E-Mail: JTarbell@gmail.com or visit the website at http://www.lm76.com
See this and other Motion Control Components from LM76 featured on:
http://LinearMotionBlogger.com
http://MotionControl-XYZ-Theta.com
http://MotionControlBlogger.com
http://MotionControlBuyersGuide.com
http://Catalogs-MotionControl.com
January 20th, 2025 Editor/Publisher 
The Motion Control RVC-9025 Rotational Voice Coil Stage provides a means to quickly and repeatably steer an optical beam with a diameter of up to 25 millimeters over 90° with 25 microradians of resolution.
Forestville, CA, — The motion control RVC-9025 provides galvo like performance at a fraction of the size and cost. It is capable of positioning a mirror anywhere within its ±22.5° mechanical range in about a millisecond with micro-radian resolution.
January 13th, 2025 Editor/Publisher 
Van Nuys, CA —– Motion Control – Optimal Engineering Systems, Inc. (OES) has unveiled their new YouTube Channel https://www.youtube.com/@oesmotioncontrolvideos. Checkout their new video featuring the AK110-10-15 Alpha-Beta Dual axis Goniometer Stage.
January 6th, 2025 Editor/Publisher 
Motion Control – Van Nuys, CA – Solenoids – The R-09-150 CCWM Series of Counter Clockwise, Forward Shaft Extension Rotary Solenoids from Magnetic Sensor Systems (MSS), available in OEM quantities, features 18 different winding configurations allowing the user to match torque and duty cycle requirements to an application.
December 31st, 2024 Editor/Publisher 
Vaughan, Ontario, Canada — Motion Control – Electromate, a leading Canadian distributor of state-of-the-art industrial automation products, is proud to announce the addition of Quantum Devices’ latest innovation, the QM22 series of optical incremental encoders, to its comprehensive portfolio.
December 24th, 2024 Editor/Publisher 
Van Nuys, CA – Motion Control – Moticont has released the HVCM-025-022-003-01 Hollow Core Voice Coil Motor, featuring an open aperture and high force-to-size ratio. This miniature Linear DC Servo Motor has a continuous force rating of 16.9 oz. (4.7 N) and a peak force of 53.5 oz (14.9 N) at a 10% duty cycle.
The extended length of the motor is 1.31 inch (33.3 mm) at mid-stroke, and has a 0.125 inch (3.2 mm) diameter open aperture for optics, illumination, laser beams, or passage of cables. Clean and quiet, this non-commutated, miniature brushless servo motor features: Zero cogging and zero backlash (when connected directly to a load), high acceleration, deceleration and high speed.
December 17th, 2024 Editor/Publisher 
Motion Control Technology Newsletter E. Longmeadow, MA – Lubrication, Lubrication Systems have always been a required – but less than desirable – facet of bearing life. What if you could go Lube-Free. For more information, call Mike Quinn 617-538-8756 email: mquinn@LM76.com
December 10th, 2024 Editor/Publisher 
Forestville, CA, – — The motion control SMS12 Linear Stepper Motor stage is an ultra compact stage that provides up to 12 millimeters of linear motion. This stage offers near sub-micron resolution with the ability to accelerate a small load at 2G’s. A non-contact home sensor provides a reference position with repeatability of a couple microns. It was specifically developed for optical applications requiring both high precision and modest-speed positioning over a short to medium stroke.
December 3rd, 2024 Editor/Publisher 
Van Nuys, CA – Motion Control – New High Precision Three-axis ZGG-60-10-15 Series of Lift, Pitch, and Roll Stages have been released by Optimal Engineering Systems, Inc. (OES). These compact motion control stages feature 60 mm +/- 2 mm (2.362 in. +/- 0.078 in.) of vertical travel.
November 26th, 2024 Editor/Publisher 
Motion Control – Van Nuys, CA –Latching Bi-Directional Solenoids released by Magnetic Sensor Systems (MSS) are low cost, economical to use, and easy to integrate into an application. The S-18-100LC2 and S-18-100LF2 Latching Bi-Directional Solenoids feature the same compact dimensions: 1.00 in. wide x 0.84 in. high x 1.73 in. long with 6-32 threaded Push/Pull plungers.
November 12th, 2024 Editor/Publisher 
Van Nuys, CA – Motion Control – A one Micron resolution linear DC motor driven stage has been released by Moticont. The high performance VCDS-025-038-02-B1-01 linear voice coil stage features high speed, high acceleration/deceleration, zero backlash, smooth motion, precise positioning, high reliability, and low cost. This non-commutated stage is clean room friendly.
November 5th, 2024 Editor/Publisher 
E. Longmeadow, MA — Motion Control – Linear Motion Bearings – FDA/USDA/3A compliant bearings, Seals, Shafting, and Pillow Blocks are available from LM76.
LM76 Fluidline BearingsTM are long wearing thermoplastic polyester self lubricating, low coefficient of friction, light weight linear bearings. Available off-the-shelf in standard closed inch sizes (closed metric sizes are available on request) these bearings drop-in replacements for standard linear bearings. They are highly resistant to wash-down chemicals and high energy radiation such as gamma and x-rays.
October 22nd, 2024 Editor/Publisher 
Van Nuys, CA – Motion Control – OES (Optimal Engineering Systems, Inc.) has added vertical stages to their extensive line of high accuracy, high resolution lift stages.
October 15th, 2024 Editor/Publisher 
Motion Control – Van Nuys, CA – Solenoids – The S-70-300H Series of high force Push Type Tubular Solenoids has been released by Magnetic Sensor Systems (MSS). Ideal for strokes of up to 4.00 inches, this series of solenoids features 18 different solenoids to select from based on the Force, Voltage, Duty Cycle, and Stroke requirement of the user. MSS Solenoids coils typically utilize Class “F” 23 to 40 AWG (American Wire Gauge) windings with Class “A” lead wire insulation for better protection of the solenoid during longer duty cycles.
October 8th, 2024 Editor/Publisher 
The new ESCON2 controller, for brushed DC and brushless DC motors up to 1,800W continuous duty, is designed for OEM integration into customer systems. ESCON2 enhances control with features including field-oriented control (FOC) and acceleration and velocity feed forward.
October 1st, 2024 Editor/Publisher 
Van Nuys, CA – Motion Control – Moticont is releasing two 12.7 mm (0.500 in.) diameter Linear Voice Coil Motors, the LVCM-013-032-02M (Metric) and the LVCM-013-032-02 (Imperial). These brushless high speed linear servo motors have a 25.4 mm 1.000 in. long stroke, and a high-force-to-size ratio of 0.70 N (2.5 oz.) and a peak force of 2.20 N (7.9 oz.) at 10% duty cycle.
Known also as moving coil motors or linear actuators they are ideal for: Dispensing, work holding and clamping, assembly, testing, wafer handling, animation, dynamic vibration absorption, scanners and laser beam steering and filtering.
September 17th, 2024 Editor/Publisher 
Forestville, CA, – Motion Control — The RVC-1008 Rotational Voice Coil Stage: Optical element widths up to 20mm; Controllable motion over +/-10 degree optical; Small step response of less than 3msec; Non-contact electro-optic position sensor; Positioning sensitivity of less than 2µrad; Analog and USB control of mirror position; Digital positioning resolution of 6µrad; Fully integrated PID servo controller; Simple USB electrical interface; Extremely compact design.
